颚式破碎机在操作中应注意的细节! - 移动式碎石机租赁

88棋牌

欢迎光临济南大黄蜂工程机械88棋牌

热门关键词:

  • 移动碎石机租赁
  • 圆锥碎石机租赁
  • 反击破碎机租赁
当前位置: 88棋牌 - 88棋牌 >
山东大黄蜂工程机械88棋牌
电    话:18366127778
地    址:济南市槐荫区经一路273号群盛华城2号楼1-404
网    址:http://www.danricelaw.com
88棋牌
颚式破碎机在操作中应注意的细节!
网址:http://www.danricelaw.com    发布时间:2019-07-31
颚式破碎机俗称鄂破,又名老虎口。由动鄂和静颚两块颚板组成破碎腔,模拟动物的两颚运动而完成物料破碎作业的破碎机。广泛运用于矿山、冶炼、建材、公路、铁路、水利和化工等行业中各种矿石与大块物料的中等粒度破碎。被破碎物料的抗压强度为320Mpa。下面移动碎石机租赁厂家就给大家总结一下这种碎石机操作中应注意的细节!
Jaw crusher is commonly known as Epu, also known as Tiger Mouth. The crusher is composed of moving jaw and static jaw, which simulates the movement of animal's two jaws and completes material crushing operation. Widely used in mining, smelting, building materials, highways, railways, water conservancy and chemical industries, all kinds of ores and bulk materials of medium size crushing. The crushed material has a compressive strength of 320 Mpa. Next mobile gravel machine rental manufacturers to summarize the details of this kind of gravel machine operation should pay attention to!
1.颚式破碎机必须空载启动。启动后如果破碎机发出不正常的敲击声,应停止运转,查明和消除弊病后,重新启动机器。启动后经过一定时间,运转正常方可开动给矿设备。给入破碎机的矿石应逐渐增加,直到满载运转,尽量避免过载。
1. Jaw crusher must start without load. If the crusher makes abnormal knocking sound after starting, it should stop running and restart the machine after identifying and eliminating the malpractice. After a certain period of time after starting, the feeding equipment can be operated normally. The ore fed into crusher should be gradually increased until full load operation, and overload should be avoided as far as possible.
2.在运行过程中,应经常注意各润滑点的润滑是否正常。注意轴承的温度,特别是偏心轴承的温度不允许超过600C。经常检查排矿口磨损情况,根据磨损情况要及时调整排矿口大小。
2. In the course of operation, attention should be paid to whether the lubrication of each lubrication point is normal. Pay attention to the bearing temperature, especially the eccentric bearing temperature is not allowed to exceed 600C. Often check the wear condition of the ore discharge port, and adjust the size of the ore discharge port in time according to the wear condition.
移动碎石家租赁
3.运行过程中,还要经常注意大矿块卡住破碎机的给矿口,如果已经卡住时,定要使用铁钩去翻动矿石,使其排除。如果矿石堵塞破碎腔,应停止给矿,待腔内矿石破碎完了再开给矿机;如果大块矿石需要从破碎腔中取出时必须停机后用专门工具处理,严禁用手去从破碎腔里取出矿石,以免发生事故。
3. In the course of operation, we should also pay attention to the large ore block jamming the feeding port of the crusher. If it has been jammed, we must use the iron hook to turn over the ore to remove it. If the ore is blocked in the crushing chamber, it should stop feeding until the ore in the chamber is crushed and opened to the miner. If the large ore needs to be removed from the crushing chamber, it must be stopped and treated with special tools. It is strictly forbidden to take the ore out of the crushing chamber by hand in order to avoid accidents.
4.运行中必须注意均匀给矿,矿石不许挤满破碎腔。同时给矿时严防电铲的铲齿和钻头等非破碎物进入破碎机。一旦发现这些非破碎物体进入破碎腔,而又通过该机器的排矿口时,应立即通知皮带运输岗位及时取出,以免进入下一段破碎机,造成严重的设备事故。
4. In operation, attention must be paid to uniform ore feeding, and ore must not be crowded into the crushing chamber. At the same time, the shovel teeth and drill bits of the electric shovel should be strictly prevented from entering the crusher. Once it is found that these non-broken objects enter the crushing chamber and pass through the discharging port of the machine, the belt transportation post should be notified immediately to take them out in time so as not to enter the next crusher and cause serious equipment accidents.
以上的精彩内容由移动碎石机租赁友情提供,更多的精彩内容请继续关注我们:http://www.danricelaw.com,我们会有更多的精彩内容为您倾情奉献!
The above wonderful content is provided by mobile lithotripter rental friendship, more wonderful content please continue to pay attention to us: http://www.danricelaw.com, we will have more wonderful content to dedicate to you!

创新驱动发展,科技引领未来,诚信铸就品牌

地址:济南市槐荫区经一路273号群盛华城2号楼1-404  电话:18366127778

CopyRight © 2018. 山东大黄蜂工程机械88棋牌 All Rights Reserved.   技术支持:   
备案号:  流量分析:


猪猪棋牌 88棋牌下载 平安彩票 平安彩票 平安彩票 88棋牌 88棋牌 平安彩票 平安彩票 平安彩票